My 97 323i windscreen washers wont work but pump is making right noise anyone had similar problems?
Answers:
ya stick a needle into the washer tips. itll loosen up whatever debris is in there. be careful though, the needle could be larger than the hole destroying the nozzle tip and then youll have to go out and buy one of those ones with the led's in them and look like a poser like the rest of those dummies that buy led windshield washer housings.
well if the pump is making noise, were half way through the problem, first disconnect the rubber line that feeds the nozzles under your hood, there will be one from your pump that will seperate into two that run to your nozzles and see if your pump will pump washer fluid. the next step is disconect the rubber hose at your nozzles and check the pump. if the nozzles are clogged, which i suspect pick up a new set at bmw they are cheep enough
Had a pipe blow apart on my Golf Gti and my Mondeo in the past. Could of happenend if the water was frozen in the pipe.
Keep trying it and see where the water comes from. Carefull though the Gti was leaking into the roof lining(rear wiper) The mondeo blew off the pump on the bottom of the bottle.
Hi, I had a simmaler problem with my vectra's washers.
If anybody has in it's history put something like washing up liqued in the washer bottle, it can slowly bung up the filter prior to the pump.
I would find the pump, carefully look how to remove it (VIA A HAYNES MANUAL)
remove the filter & clean & replace it.
If having done this, it still doesn't work, then follow the rubber tubing from the pump, and look for a round disc about the size of a penny.
This is a 1 way valve, there is a chance this could be blocked, or broken.
Try releasing the tubing before it & spray as normal, if this comes out quickly, then replace, the rubber & remove the other side, if the flow is weak, then replace the valve.
you may find the washer pipe is blocked.try removing the pipe from the jets.if the pump woks then you need to back blow the jets to remove the blockage if this does not work disconect the pipe from the pump and try the washers,if the pump is still noisey it will be part-sezied and will need replacing.
just dirt in your jet nozzles very common with all cars try a small sewing needle into the jet n wiggle to break up the dirt the jets can move so u need to keep checkin them once they squirt again then just put the needle back in n move the jet up or down to higher or lower the water jet on ur windscreen it is very simple to do
The answers post by the user, for information only, UKQnA.com does not guarantee the right.